Real-life H&S incidents
Timber-frame firm fined for fire safety and traffic offences
Written by Phoenix Health & Safety
5th September 2016
Timber-frame firm fined for fire safety and traffic offences.
Cwmbran Magistrates’ Court heard that HSE launched an investigation on 27 July after making an unannounced visit to inspect Hale’s site in the centre of Blaenavon.
Fifty-four timber-frame houses were under construction, which carry a serious fire risk if not planned or managed properly, as the structures are made from wood. If a fire starts, the speed and intensity of fire spread can be extreme – putting workers and even members of the public at risk of harm.
HSE found that measures to prevent a fire starting and getting out of control had not been properly taken. All the houses were under construction at broadly the same stage with little fire protection, a lack of site management control, insufficient means to detect a fire and raise the alarm, poor control of ignition sources and a general lack of emergency planning. Workers were also at risk of being struck or crushed by construction vehicles on site.
Improvement Notices were served regarding fire and vehicle safety issues and these were complied with after two further inspection visits.
J G Hale Construction Limited, of Milland Road, Neath, South Wales, who also manufacture timber frames for the construction industry, pleaded guilty to breaching Regulations 27 and 29 of the Construction (Design and Management) Regulations 2015, and was fined £40,000 and £60,000 respectively. They were ordered to pay full prosecution costs of £4633.76 and a statutory surcharge of £120.
After the hearing, HSE inspector Liam Osborne said: “Hale Construction had been given plenty of warnings about fire-safety and traffic risks in the recent past, including from HSE.
“Timber-frame houses are perfectly safe once they’re finished and protected, but when under construction they can be very dangerous. Stringent fire-safety standards need to be in place well before the build starts, and then maintained and monitored".
Phoenix comment “The CDM Regulations clearly state the requirement to eliminate and controlling the risks from fire (Regs 29) and organised traffic routes so that pedestrians and vehicles can move without risks to health or safety (Reg 27). Thorough planning will reduce dynamic risks during the construction phase and offer the same level of safety protection required for all workers through the project”.